Chigo Split Floor-Standing Air Conditioner Manuel de service

SplitairconditionerWallmountedTypeServicemanualMXI 09HC001- /MXO-09HC001MXI 12HC001- /MXO-12HC001MBFRIGOGrupad.o.o.,Bani81,10010 Zagreb,

GRUPAd.o.o.BurrObliqueCopper pipe90RoughnessReamerBurr Outer diameter A(mm)2.0--2.53.0--3.53.5--4.06.35mm ( 1/4 )9.52mm ( 3/

GRUPAd.o.o.Screw the gas shut-off valve to close, connect charging hose(low pressure) to the service valve and then open gas shut-off

GRUPAd.o.o.Operation test8Before test operation, wiring safety inspection must be carried out carefully again.1. Emergency switch oper

GRUPAd.o.o.TROUBLE SHOOTING Items to be checked first1. Is the voltage of the power correct? The input voltage shall be rating volt

GRUPAd.o.o.FAULT DIAGNOSIS BY SYMPTOM No cooling effect at allFan motor errorFan motor or its capacitor faults.Loose connection or bad

GRUPAd.o.o. No heating effect at allFan motor errorFan motor or its capacitor faults.Loose connection or badly contact.compressor does

GRUPAd.o.o. Noise from indoor unitCollision sound of the machineFlowing sound of the liquidSound of the running fan motorSound of plas

GRUPAd.o.o. Switching on the air conditioner The current leakage switch jumps to turn off Junction wire loos

GRUPAd.o.o.CONTROL SPECIFICATION1122ABBREVIATIONST: Setting TemperaturePT: Indoor coil Pipe TemperatureRT: Room TemperatureOT: Outdoor

GRUPAd.o.o.HEAT MODEIf the air conditioner is off and then turned on while set at COOL ,HEAT or DRY mode, it will take approximately 3

GRUPAd.o.o.1 CONTENTS11ContentsSafety precautionsInstallation 1111Block diagram1212Trouble shooting1313Fault diagnosis by symptom1717

GRUPAd.o.o.DRY MODEIn this mode, the air conditioner automatically sets the room temperature and this temperatureis incontrollable by

GRUPAd.o.o.FAN MODEIndoor fan runs at the set speed while compressor and outdoor fan are turned off.Indoor fan speed can be adjusted f

GRUPAd.o.o.Stop operation of the air conditioner and remove the power cord before repairing the unit.Indoor unit No Parts Procedure Re

GRUPAd.o.o.4.Separate the electrical box from the indoor unit. 1.Loosen the earth screw in evaporator.2.Loosen the sull s

GRUPAd.o.o.3.Separate the evaporator from the indoor unit.4Evaporator2.Separete the ass’y tray drain from the body.1.Push the left

GRUPAd.o.o.Outdoor unit1 Cabinet 1.Turn off the unit and remove the power cable.2.Remove the upper cabinet, the front cabi

GRUPAd.o.o.Indoor unitExploded Views and Parts List25AUS-07C(H)53R010LxAUS-12C(H)53R130LxAUS-12C(H)53R150LxAUS-09C(H)53R010LxGRU

GRUPAd.o.o.Exploded Views and Parts List26Indoor unitNo. English Part Name qty.remarkNo. English Part Name qty.remark1 air filter 2l

GRUPAd.o.o.Outdoor unitExploded Views and Parts List27AUS-07C53R010Lx AUS-09C53R010LxGRUPAd.o.o.

GRUPAd.o.o.Exploded Views and Parts List28Outdoor unitNo. English Part Name Quantity No. English Part Name Quantity1 Air outlet gril

GRUPAd.o.o.The following safety precautions must be taken when using your air conditioner.SAFETY PRECAUTIONS1. Warning: Prior to repai

GRUPAd.o.o.Outdoor unitExploded Views and Parts List29AUS-07H53R010Lx AUS-09H53R010LxGRUPAd.o.o.

GRUPAd.o.o.Exploded Views and Parts List30Outdoor unitNumberNameQuantity NumberNameQuantity1 Air outlet grille 1 28 Right handle 12 Fr

GRUPAd.o.o.Outdoor unitExploded Views and Parts List31AUS-12C53R150LxGRUPAd.o.o.

GRUPAd.o.o.Outdoor unitExploded Views and Parts ListNo English Part Name Quantity No. English Part Name Quantity1 Air outlet grille 1

GRUPAd.o.o.Outdoor unitExploded Views and Parts List33AUS-12H53R150LxGRUPAd.o.o.

GRUPAd.o.o.No. English Part Name Quantity No. English Part Name Quantity1 Air outlet grille 1 26 Right handle 12 Front panel 1 27 Ou

GRUPAd.o.o.Outdoor unitExploded Views and Parts List35AUS-12C53R130LxGRUPAd.o.o.

GRUPAd.o.o.Exploded Views and Parts List36Outdoor unitNo. English Part Name Quantity No. English Part Name Quantity1 Air outlet gril

GRUPAd.o.o.Exploded Views and Parts ListOutdoor unit37AUS-12H53R130LxGRUPAd.o.o.

GRUPAd.o.o.Exploded Views and Parts List38Outdoor unitNo. English Part Name Quantity No. English Part Name Quantity1 Air outlet gril

GRUPAd.o.o.frontrightbackUndersideLeft-backbackNotice: do not elevate the drain hose.The copper pipe can be ledfrom back, right, unde

GRUPAd.o.o.Wiring DiagramsIndoor unitOutdoor unit39AUS-07C53R010LxAUS-09C53R010LxAUS-12C53R150LxAUS-12C53R130LxAUS-07C53R010LxAUS-09C5

GRUPAd.o.o.Wiring DiagramsIndoor unitAUS-07H53R010Lx Outdoor unit40AUS-12H53R130LxAUS-09H53R010LxAUS-07H53R010Lx AUS-12H53R130LxAU

GRUPAd.o.o.Wiring DiagramsIndoor unitAUS-12H53R150LxOutdoor unit41AUS-12H53R150LxIFANGRUPAd.o.o.

GRUPAd.o.o. Securing the mounting plate and drill on the wall 1 Secure the mounting plateThe mounting plate should be attached to the

GRUPAd.o.o. Wiring2Open the front grille;Remove the screw from electrical box cover, pull the electrical box cover away from the unit

GRUPAd.o.o.Arrangement of the drain hoseTo drain the condensate water easily, the drain hose should be declined downwards.The followin

GRUPAd.o.o.INSTALLATIONConnectingcableOutdoor unit terminal1 Wiring1 Remove the self-tapping screws (2 pcs) on the maintenance board

GRUPAd.o.o.8INSTALLATIONIf the interconnection cord for power supply has to be replaced, please see the following table for reference.